Food Establishment Inspection Report
Page 1  of ????????? 
KANKAKEE COUNTY HEALTH DEPARTMENT
 2390 W. Station Street
Kankakee, IL 60901
Phone: (815) 802 - 9410
Establishment
 GONZALEZ GROCERY 		License/Permit #
 KK071
Street Address
1933 E COURT ST
City/State
 KANKAKEE, IL 		ZIP Code
 60901
No. of Risk Factor/Intervention Violations 7
No. of Repeat Risk Factor/Intervention Violations 0
Date 09/27/2021
Time In 01:55 PM
Time Out 04:00 PM
Permit Holder
CALDERON, LILIANA 		Risk Category
H
Purpose of Inspection
ORIGINAL INSPECTION

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible    

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated X  
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures X  
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used    

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection  
R
=repeat violation  
Compliance Status
 COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
Compliance Status
 COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47 X Food & non-food contact surfaces cleanable, properly designed, constructed & used   X
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean   X

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51 X Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54 X Garbage & refuse properly disposed; facilities maintained X  
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    
58 X Allergen training as required   X
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: GONZALEZ GROCERY Establishment #: KK071
Water Supply:   Public Private   Waste Water System:   Public Private
Sanitizer Type: Chemical PPM: CHLORINE 100 Heat: NA °F
CFPM Verification (name, ID#, expiration date):


01/01/1900

01/01/1900

01/01/1900

 

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
Salsa/Prep cooler 34.00°F Refried beans/Sliding door cooler 36.00°F Chicken/Deli cooler 36.00°F
Sausage/Deli Cooler 36.00°F Beef/Deli cooler 38.00°F /Back room refrigerator 37.00°F
Beef/Walk-in cooler 41.00°F /Grocery cooler 38.00°F /Grocery cooler 2 43.00°F
/Grocery cooler 3 37.00°F /8 chest freezers/back room 0.00°F /Ice cream freezer 0.00°F
/Kitchen freezer 0.00°F Pork/Stovetop 158.00°F Pork/Stovetop-in broth 130.00°F

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Severity Violations cited in this report must be corrected within the time frames below.
6 C 2-401.11: (A) Except as specified in ¶ (B) of this section, an EMPLOYEE shall eat, drink, or use any form of tobacco only in designated areas where the contamination of exposed FOOD; clean EQUIPMENT, UTENSILS, and LINENS; unwrapped SINGLE-SERVICE and SINGLE-USE ARTICLES; or other items needing protection can not result. (B) A FOOD EMPLOYEE may drink from a closed BEVERAGE container if the container is handled to prevent contamination of: (1) The EMPLOYEE'S hands; (2) The container; and (3) Exposed FOOD; clean EQUIPMENT, UTENSILS, and LINENS; and unwrapped SINGLE-SERVICE and SINGLE-USE ARTICLES.
Food was eaten at the prep station in the kitchen area with a number of food products close by. Eat and store personal food only in designated areas and maintain by the next routine inspection.
11 PF 3-201.11 (C): (C) PACKAGED FOOD shall be labeled as specified in LAW, including 21 CFR 101 FOOD Labeling, 9 CFR 317 Labeling, Marking Devices, and Containers, and 9 CFR 381 Subpart N Labeling and Containers, and as specified under §§ 3-202.17 and 3-202.18.
A number of products produced on premises do not have retail labels. - (Correct By: Oct 7, 2021)
13 P 3-101.11: FOOD shall be safe, unADULTERATED, and, as specified under § 3-601.12, honestly presented.
Several packages of sliced papaya were spoiled in the grocery cooler. Packages were discarded. COS
15 P 3-302.11 (A) (2): (A) FOOD shall be protected from cross contamination by:   (2) Except when combined as ingredients, separating types of raw animal FOODS from each other such as beef, FISH, lamb, pork, and POULTRY during storage, preparation, holding, and display by: (a) Using separate EQUIPMENT for each type, or (b) Arranging each type of FOOD in EQUIPMENT so that cross contamination of one type with another is prevented, and (c) Preparing each type of FOOD at different times or in separate areas.
In several coolers and freezers in the establishment, raw meat products were stored above ready to eat foods. - (Correct By: Sep 30, 2021)
16 PF 4-601.11(A): (A) EQUIPMENT FOOD-CONTACT SURFACES and UTENSILS shall be clean to sight and touch.
The following food contact surfaces are in need of cleaning: 1)Interior of microwave in kitchen, 2)Underside of the meat slicer at the meat counter, 3)Deflector of the ice machine. - (Correct By: Oct 7, 2021)
20 P 3-501.14 (A): (A) Cooked TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be cooled: (1) Within 2 hours from 57ºC (135ºF) to 21ºC (70°F); and (2) Within a total of 6 hours from 57ºC (135ºF) to 5ºC (41°F) or less.
Many products stored throughout the establishment that went through the cooling process are not labeled with the time of preparation. - (Correct By: Sep 30, 2021)
21 P 3-501.16(A)(1): (A) Except during preparation, cooking, or cooling, or when time is used as the public health control as specified under §3-501.19, and except as specified under ¶ (B) and in ¶ (C ) of this section, TIME/TEMPERATURE CONTROL FOR SAFETY FOOD shall be maintained: (1)At 57°C (135°F) or above, except that roasts cooked to a temperature and for a time specified in ¶ 3-401.11(B) or reheated as specified in ¶ 3-403.11(E) may be held at a temperature of 54°C (130°F) or above.
Pork held in a broth on the back room stove top was at 130 degrees under no temperature control. This broth was heated back to 135 degrees. COS
47 C 4-101.19: NonFOOD-CONTACT SURFACES of EQUIPMENT that are exposed to splash, spillage, or other FOOD soiling or that require frequent cleaning shall be constructed of a CORROSION-RESISTANT, nonabsorbent, and SMOOTH material.
A piece of untreated wood is attached to the wall behind the flat top grill in the kitchen area. Stain or paint this wood and maintain by the next routine inspection. Repeat
47 C 4-501.11 (A): (A) EQUIPMENT shall be maintained in a state of repair and condition that meets the requirements specified under Parts 4-1 and 4-2.
Inside the prep cooler in the kitchen, the pans holding the small cups of salsa and the shelf below are rusty. Remove the rust or replace and maintain by the next routine inspection. Repeat
49 C 4-602.13: NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues.
The following non-food contact surfaces are in need of cleaning: 1)Gasket of the prep cooler in the kitchen, 2)Interior of the sliding door cooler at the kitchen, 3)Interior of the deli cooler. Clean and maintain by the next routine inspection. Repeat
51 C 5-205.15 (B): A PLUMBING SYSTEM shall be(B) Maintained in good repair.
The hand wash sink at the meat counter is not attached to the wall. Repair and maintain by the next routine inspection.
54 C 5-501.113: Receptacles and waste handling units for REFUSE, recyclables, and returnables shall be kept covered: (A)Inside the FOOD ESTABLISHMENT if the receptacles and units: (1)Contain FOOD residue and are not in continuous use; or (2)After they are filled; and (B)With tight-fitting lids or doors if kept outside the FOOD ESTABLISHMENT.
The dumpster lid was open. Keep the lid closed and maintain by the next routine inspection. COS
58 Violation: Not all certified Food protection managers have completed allergen awareness training. Corrective Action: All employees that are certified food safety managers shall completed allergen awareness training by the next routine inspection. Repeat
HACCP Topic: PROPER COOLING PROCEDURES: COOL FOODS FROM 135 TO 71 WITHIN 2 HOURS, FROM 71 TO 41 WITHIN AN ADDITIONAL 4 HOURS, 6 HOURS TOTAL. LABEL ALL COOLING FOOD WITH THE TIME OF PREPARATION.
 

Person In Charge

  ALEJANDRO MEDINA 		 

Date:

  09/27/2021
 

Inspector

  DANA JAMES 		 

Follow-up:  Yes   No   Follow-up Date:

09/30/2021